Study on the discharge coefficient of wind-driven naturally ventilated Chinese solar greenhouses
)Abstract
The Chinese solar greenhouse (CSG) is a prevalent feature in agricultural practices within China. Nevertheless, the regulation of natural ventilation within this architectural structure remains suboptimal. Consequently, the development of a natural ventilation model becomes imperative for the effective management of the greenhouse environment. Of particular significance within these models is the consideration of the discharge coefficient as a pivotal parameter. Conducting a multi-case investigation into the variable-dependent discharge coefficient is crucial for both practical application and model advancement. This research delved into the impact of various factors, including the upper-lower vents area ratio (Aup/Alow), vent-greenhouse area ratio (Alow/Agreenhouse), lower vent position height (h/H), the incident angle of the external wind, and altitude, on the discharge coefficient (Cd) of CSG. A CFD model was developed for a scaled CSG with validation conducted through field experiments and wind tunnel tests. Results indicated a 61.6% reduction in Cd on average corresponding to an 80% decrease in Aup/Alow. Cd levels remained consistent following the attainment of an Aup/Alow ratio of 1.0. Besides, there was an average increase of 52.5% in Cd levels for every 0.09 decline in h/H, attributed to the blocking effect of the cover. Moreover, the ventilation rate and the pressure coefficient difference were utilized to construct a model of Cd pertaining to greenhouse design and ventilation operation, exhibiting a notable accuracy level of R2 = 0.95. Furthermore, the blocking effect of higher h/H was relieved as the incident angle θ decreased under the windward conditions. The increase in Aup/Alow and the decrease in Alow/Agreenhouse were identified as crucial factors contributing to the growth of Cd under leeward conditions. Ultimately, the high-altitude environment led to a rise in Cd levels in contrast to the low-altitude region. The increasing rate of Cd correlated positively with Alow/Agreenhouse and h/H initially, but exhibited a decline once Alow/Agreenhouse reached 0.036, remaining stable thereafter once h/H reached 0.18. In summary, a comprehensive examination of the discharge coefficient of CSG was undertaken, addressing a significant knowledge deficiency and laying the groundwork for advancements in the natural ventilation model and the intelligent control system for CSG.
Keywords
Electronic Supplementary Material
References
Baptista FJ, Bailey BJ, Randall JM, et al. (1999). Greenhouse ventilation rate: Theory and measurement with tracer gas techniques. Journal of Agricultural Engineering Research, 72: 363–374.
Boulard T, Baille A (1995). Modelling of air exchange rate in a greenhouse equipped with continuous roof vents. Journal of Agricultural Engineering Research, 61: 37–47.
Boulard T, Meneses JF, Mermier M, et al. (1996). The mechanisms involved in the natural ventilation of greenhouses. Agricultural and Forest Meteorology, 79: 61–77.
Bruce JM (1978). Natural convection through openings and its application to cattle building ventilation. Journal of Agricultural Engineering Research, 23: 151–167.
Chu CR, Chiu YH, Chen YJ, et al. (2009). Turbulence effects on the discharge coefficient and mean flow rate of wind-driven cross-ventilation. Building and Environment, 44: 2064–2072.
Chu CR, Lan T, Tasi R, et al. (2017). Wind-driven natural ventilation of greenhouses with vegetation. Biosystems Engineering, 164: 221–234.
Chu CR, Lan T (2019). Effectiveness of ridge vent to wind-driven natural ventilation in monoslope multi-span greenhouses. Biosystems Engineering, 186: 279–292.
De Jong T, Bot GPA (1992). Flow characteristics of one-side-mounted windows. Energy and Buildings, 19: 105–112.
Evola G, Popov V (2006). Computational analysis of wind driven natural ventilation in buildings. Energy and Buildings, 38: 491–501.
Fang H, Yang Q, Zhang Y, et al. (2016). Simulation on ventilation flux of solar greenhouse based on the coupling between stack and wind effects. Chinese Journal of Agrometeorology, 37: 531–537. (in Chinese)
Fatnassi H, Boulard T, Bouirden L (2013). Development, validation and use of a dynamic model for simulate the climate conditions in a large scale greenhouse equipped with insect-proof nets. Computers and Electronics in Agriculture, 98: 54–61.
Fu W, You S (2013). The influence of intake size of strawberry solar greenhouse on the microclimate in natural ventilation: An experimental study. Journal of Hebei University of Technology, 42(03): 52–56. (in Chinese)
Kittas C, Boulard T, Mermier M, et al. (1996). Wind induced air exchange rates in a greenhouse tunnel with continuous side openings. Journal of Agricultural Engineering Research, 65: 37–49.
Kittas C, Boulard T, Papadakis G (1997). Natural ventilation of a greenhouse with ridge and side openings: sensitivity to temperature and wind effects. Transactions of the ASAE, 40: 415–425.
Li B, Ford SE, Li Y, et al. (2006). Development of a fan testing chamber for agricultural and horticultural fans in China. Applied Engineering in Agriculture, 22: 115–119.
Liang B, Zhao S, Li Y, et al. (2022). Study on the natural ventilation characteristics of a solar greenhouse in a high-altitude area. Agronomy, 12: 2387.
Liu S, He Y, Zhang Y, Miao X (2005). Prediction and analysis model of temperature and its application to a natural ventilation multi-span plastic greenhouse equipped with insect-proof screen. Journal of Zhejiang University: Science B, 6: 523–529.
Mashonjowa E, Ronsse F, Milford JR, et al. (2010). Measurement and simulation of the ventilation rates in a naturally ventilated azrom-type greenhouse in Zimbabwe. Applied Engineering in Agriculture, 26: 475–488.
Mashonjowa E, Ronsse F, Milford JR, et al. (2013). Modelling the thermal performance of a naturally ventilated greenhouse in Zimbabwe using a dynamic greenhouse climate model. Solar Energy, 91: 381–393.
Oca J, Montero JI, Antón A, et al. (1999). A method for studying natural ventilation by thermal effects in a tunnel greenhouse using laboratory-scale models. Journal of Agricultural Engineering Research, 72: 93–104.
Ohba M, Lun I (2010). Overview of natural cross-ventilation studies and the latest simulation design tools used in building ventilation- related research. Advances in Building Energy Research, 4: 127–166.
Pérez Parra JP, Baeza E, Montero JI, et al. (2004). Natural ventilation of parral greenhouses. Biosystems Engineering, 87: 355–366.
Ramponi R, Blocken B (2012). CFD simulation of cross-ventilation for a generic isolated building: Impact of computational parameters. Building and Environment, 53: 34–48.
Si H, Miao X (2005). Opening model of natural vent ilation windows for East-China Multi-span Plast ic Greenhouse and studies on it. Journal of Zhejiang University, 31(01): 113–118. (in Chinese)
Snyder WH (1972). Similarity criteria for the application of fluid models to the study of air pollution meteorology. Boundary-Layer Meteorology, 3: 113–134.
Teitel M, Tanny J (1999). Natural ventilation of greenhouses: experiments and model. Agricultural and Forest Meteorology, 96: 59–70.
Yi Q, Zhang G, König M, et al. (2018). Investigation of discharge coefficient for wind-driven naturally ventilated dairy barns. Energy and Buildings, 165: 132–140.
Yi Q, Li H, Wang X, et al. (2019). Numerical investigation on the effects of building configuration on discharge coefficient for a cross-ventilated dairy building model. Biosystems Engineering, 182: 107–122.
Zhang Q, Yu H, Zhang Z, et al. (2012). Airflow simulation in solar greenhouse using CFD model. Transactions of the Chinese Society of Agricultural Engineering, 28(16): 166–171.
Zhang J, Zhao S, Dai A, et al. (2022). Greenhouse natural ventilation models: how do we develop with Chinese greenhouses? Agronomy, 12: 1995.
Zhou J, Zhang G, Xu Y, et al. (2006). Discussion on influencing factors of opening discharge coefficient in natural ventilation. Heating Ventilating & Air Conditioning, 36(12): 42–45. (in Chinese)
京公网安备11010802044758号