AI Chat Paper
Note: Please note that the following content is generated by AMiner AI. SciOpen does not take any responsibility related to this content.
{{lang === 'zh_CN' ? '文章概述' : 'Summary'}}
{{lang === 'en_US' ? '中' : 'Eng'}}
Chat more with AI
Article Link
Collect
Show Outline
Outline
Show full outline
Hide outline
Outline
Show full outline
Hide outline
Full Length Article | Open Access

Hot deformation behavior and strain compensation constitutive model of equiaxed fine grain diffusion-welded micro-duplex TC4 titanium alloy

Can LI,( )Imran SARDAR MUHAMMADLihui LANGYingjian GUOXiaoxing LISergei ALEXANDROVADexin ZHANG
School of Mechanical Engineering and Automation, Beihang University, Beijing 100191, China

Peer review under responsibility of Editorial Committee of CJA.

Show Author Information

Abstract

In this work, two-stage diffusion bonding of micro-duplex TC4 titanium alloy was carried out to study the flow behavior and constitutive models of the bonding joint and the base metal after the same thermal cycling during the hot forming process. Microstructure and mechanical properties test were used to verify the good quality of the equiaxed fine grain diffusion-welded TC4 alloy. Quasi-static tensile experiment was carried out at temperatures ranging from 750–900 ℃ and strain rates of 0.0001–0.1 s−1. The joint showed the weak dynamic recovery at strain rates of 0.01–0.1 s−1 and temperatures of 750–850 ℃. At strain rates of 0.0001–0.001 s−1 and temperatures of 850–900 ℃, the flow stress of joint presented steady-state characteristics. Different deformation conditions lead to the remarkable difference of dynamic softening performance between the joint and heat-treated base metal, but the flow stress in elastic and strain hardening stages exhibited similar behavior. The strain compensated Arrhenius-type constitutive models of TC4 joint and heat-treated base metal were developed respectively. The fifth-order polynomial functions between the material property correlation coefficients and strain were obtained. The models have shown good correlation, with correlation coefficient values of 0.984 and 0.99. The percentage average absolute relative error for the models were found to be 10% and 9.46%, respectively.

References

1

Hefti LD. Advances in fabricating superplastically formed and diffusion bonded components for aerospace structures. J Mater Eng Perform 2004;13(6):678–82.

2

Xun YW, Tan MJ. Applications of superplastic forming and diffusion bonding to hollow engine blades. J Mater Process Tech 2000;99(1–3):80–5.

3

Hefti LD. Innovations in the superplastic forming and diffusion bonded process. J Mater Eng Perform 2008;17(2):178–82.

4

Larsen J. Application of titanium alloy superplastic forming/diffusion bonding in air-to-air missile rudder and wing. Aeronaut Manuf Technol 2014;3:95–97 [Chinese].

5

Chandrappa K, Sumukha CS, Sankarsh BB, et al. Superplastic forming with diffusion bonding of titanium alloys. Mater Today Proc 2020;27:2909–13.

6

Lee HS, Yoon JH, Yi YM, et al. Superplastic characteristics and diffusion bonding of Ti-6Al-4V alloy. Key Eng Mater 2007;345–346:549–52.

7

Zhang T, Sha HP, Li L, et al. Study of macroscopic defects of four-layer structure of Ti-6Al-4V during superplastic forming/diffusion bonding. Int J Precis Eng Manuf 2021;22(1):27–39.

8

Mosleh AO, Mikhaylovskaya AV, Kotov AD, et al. Experimental, modelling and simulation of an approach for optimizing the superplastic forming of Ti-6%Al-4%V titanium alloy. J Manuf Process 2019;45:262–72.

9

Trân R, Reuther F, Winter S, et al. Process development for a superplastic hot tube gas forming process of titanium (Ti-3Al-2.5V) hollow profiles. Metals 2020;10(9):1150.

10
Australian Transport Safety Bureau. Engine failure involvingAirbus. Canberra: Australian Capital Territory; 2020. ATSBReport No.: AO2017066.
11
Hao Y, Li ZQ, Du FR, et al. Research on wide-chord hollow fanblade technology of large bypass ratio turbofan engine. Proceedings of the symposium on key technology of large aircraft andChina aeronautical society; 2007 Sep 2-3; Shenzhen, China.Beijing: Chinese Society of Aeronautics; 2007 [Chinese].
12

Wu XC, Chen MH, Xie LS, et al. Twist-bend forming of aeroengine titanium TC4 wide-chord hollow fan blade with complex geometries. Acta Aeronaut Astronaut Sin 2015;36(6):2055–63 [Chinese].

13

Bichon M, Douguet Charles JP, Lorieux Alain GH, et al. 5636440 Process for manufacturing a hollow blade for a turbo-machine. Comput Integr Manuf Syst 1997;10(3):245.

14

Chen MH, Wu XC, Xie LS, et al. Two-layer process and optimal blank design for hollow titanium wide-chord fan blades with complex geometries. Rare Metal Mat Eng 2019;48(6):1717–24.

15

Liu J, Tan MJ, Aue-u-lan Y, et al. Superplastic-like forming of Ti-6Al-4V alloy. Int J Adv Manuf Technol 2013;69(5):1097–104.

16

Lagos M, Retamal C. An alternate theoretical approach to solid-state bonding. Scr Mater 2011;64(5):402–5.

17
Fu ZX. Study on dynamic process and model of diffusionconnection [dissertation]. Xi’an: Northwestern PolytechnicalUniversity; 1999 [Chinese].
18

Gao FY, Wu HM, Qiu SW, et al. Study on microstructure and properties of FSW welded joint of aluminum alloy. Develop Appl Mater 2015;30(5):25–30 [Chinese].

19

Travyanov AY, Petrovsky PV, Cheverikin VV, et al. Microstructure and mechanical properties of titanium alloy VT6 and VT20L diffusion joints. Metallurgist 2022;65(9):1133–41.

20

Xiong JH, Gao FY, Chen B, et al. Vacuum diffusion bonding of TC4 titanium alloy. Trans Nonferrous Met Soc China 2013;23(1):198–201 [Chinese].

21

Balasubramanian M. Development of processing windows for diffusion bonding of Ti-6Al-4V titanium alloy and 304 stainless steel with silver as intermediate layer. Trans Nonferrous Met Soc China 2015;25(9):2932–8.

22

Yang M, Wu X, Gong XF, et al. Interfacial microstructure and mechanical properties of TC4 titanium alloy/316L stainless steel joint brazed with Ag70.5Cu27.5Ti2 filler metal. Trans Indian Inst Met 2021;74(8):1907–16.

23

Zhao WL, Liu XG, Xie PY, et al. Study on shear fatigue performance of TC4 titanium alloy diffusion bonded joints. Aeroengine 2020;46(3):99–102 [Chinese].

24

Zhang H, Li JL, Ma PY, et al. Study on microstructure and impact toughness of TC4 titanium alloy diffusion bonding joint. Vacuum 2018;152:272–7.

25

Du YJ, Xiong JT, Jin F, et al. Microstructure evolution and mechanical properties of diffusion bonding Al5(TiZrHfNb)95 refractory high entropy alloy to Ti2AlNb alloy. Mater Sci Eng A 2021;802:140610.

26

Xu WF, Ma J, Luo YX, et al. Microstructure and high-temperature mechanical properties of laser beam welded TC4/TA15 dissimilar titanium alloy joints. Trans Nonferrous Met Soc China 2020;30(1):160–70.

27

Jackson M, Jones NG, Dye D, et al. Effect of initial microstructure on plastic flow behaviour during isothermal forging of Ti-10V-2Fe-3Al. Mater Sci Eng A 2009;501(1–2):248–54.

28

Zyguła K, Wojtaszek M, Śleboda T, et al. The analysis of hot deformation behavior of powder metallurgy Ti-10V-2Fe-3Al alloy using activation energy and Zener-Hollomon parameter. Procedia Manuf 2020;50:546–51.

29

Bai DN, Gao PF, Yan XG, et al. Intelligent forming technology: state-of-the-art review and perspectives. J Adv Manuf Sci Technol 2021;1(3):2021008.

30

Souza PM, Beladi H, Singh R, et al. Constitutive analysis of hot deformation behavior of a Ti6Al4V alloy using physical based model. Mater Sci Eng A 2015;648:265–73.

31

Lin YC, Wu Q, Pang GD, et al. Hot tensile deformation mechanism and dynamic softening behavior of Ti-6Al-4V alloy with thick lamellar microstructures. Adv Eng Mater 2020;22(3):1901193.

32

Feng PN, Yang CP, Wang BY, et al. Formability and microstructure of TC4 titanium alloy hollow shafts formed by cross-wedge rolling with a mandrel. Int J Adv Manuf Technol 2021;114(1):365–77.

33

Xia YF, Jiang W, Cheng Q, et al. Hot deformation behavior of Ti-6Al-4V-0.1Ru alloy during isothermal compression. Trans Nonferrous Met Soc China 2020;30(1):134–46.

34

Zhang C, Li XQ, Li DS, et al. Modelization and comparison of Norton-Hoff and Arrhenius constitutive laws to predict hot tensile behavior of Ti-6Al-4V alloy. Trans Nonferrous Met Soc China 2012;22:457–64.

35

Lin YC, Chen MS, Zhong J. Constitutive modeling for elevated temperature flow behavior of 42CrMo steel. Comput Mater Sci 2008;42(3):470–7.

36

Xiao YH, Guo C. Constitutive modelling for high temperature behavior of 1Cr12Ni3Mo2VNbN martensitic steel. Mater Sci Eng A 2011;528(15):5081–7.

37

Liu JL, Zeng WD, Xie YJ, et al. Constitutive model of TC4-DT titanium alloy at elevated temperature considering compensation of strain. Rare Metal Mat Eng 2015;44(11):2742–6.

38

Yang S, Li H, Luo J, et al. Prediction model for flow stress during isothermal compression in α + β phase field of TC4 alloy. Rare Met 2018;37(5):369–75.

39

Lypchanskyi O, Śleboda T, Łukaszek-Sołek A, et al. Application of the strain compensation model and processing maps for description of hot deformation behavior of metastable β titanium alloy. Materials (Basel) 2021;14(8):2021.

40

Wang KH, Liu G, Zhao J, et al. Formability and microstructure evolution for hot gas forming of laser-welded TA15 titanium alloy tubes. Mater Des 2016;91:269–77.

41
Yang L. Micromechanical behavior of weld zone indiffusion welding of titanium alloy [dissertation]. Nanjing: Nanjing University of Aeronautics and Astronautics; 2017[Chinese].
42

Tang B, Wang WY, Zhu L, et al. Hot deformation study and interface characterization for TiAl/Ti2AlNb diffusion bonds based on the serial constitutive model. Intermetallics 2019;104:66–73.

43

Deepak P, Latheesh VM, Sumesh A, et al. A finite element analysis of dissimilar materials diffusion bonded joints. Mater Today Proc 2018;5(5):12484–9.

44

Liu ZG, Li PJ, Xiong LT, et al. High-temperature tensile deformation behavior and microstructure evolution of Ti55 titanium alloy. Mater Sci Eng A 2017;680:259–69.

45

Park CH, Kim JH, Hyun YT, et al. The origins of flow softening during high-temperature deformation of a Ti-6Al-4V alloy with a lamellar microstructure. J Alloys Compd 2014;582:126–9.

46

Cai J, Li FG, Liu TY, et al. Constitutive equations for elevated temperature flow stress of Ti-6Al-4V alloy considering the effect of strain. Mater Des 2011;32(3):1144–51.

47

Zener C, Hollomon JH. Effect of strain rate upon plastic flow of steel. J Appl Phys 1944;15(1):22–32.

48

Sellars CM, McTegart WJ. On the mechanism of hot deformation. Acta Metall 1966;14(9):1136–8.

49

Wang H, Zhao KX, Chu XR, et al. Constitutive modelling and microscopic analysis of TC4 alloy sheet at elevated temperature. Results Phys 2019;13:102332.

Chinese Journal of Aeronautics
Pages 510-522
Cite this article:
LI C, SARDAR MUHAMMAD I, LANG L, et al. Hot deformation behavior and strain compensation constitutive model of equiaxed fine grain diffusion-welded micro-duplex TC4 titanium alloy. Chinese Journal of Aeronautics, 2023, 36(4): 510-522. https://doi.org/10.1016/j.cja.2022.07.025

27

Views

6

Crossref

4

Web of Science

4

Scopus

Altmetrics

Received: 13 March 2022
Revised: 06 April 2022
Accepted: 20 June 2022
Published: 06 August 2022
© 2022 Chinese Society of Aeronautics and Astronautics.

This is an open access article under the CC BY-NC-ND license (http://creativecommons.org/licenses/by-nc-nd/4.0/).

Return